Driver Mechanical Breakdown Warranty

Our peace of mind warranty

Warranty

The following mechanical or electrical items are covered

Engine

Cylinder Block (excluding cracks and porosity), cylinder bores and liners (excluding cracks and porosity), crankshaft, crank main bearings, big end bearings, oil pump, con-rods, gudgeon pins, small end bearings, pistons, piston rings, cylinder head (excluding cracks, porosity), rocker shaft, rockers, hydraulic lifters, camshaft and cam followers, push rods, camshaft bearings, inlet and exhaust valves, valve springs, valve guides, cylinder head gasket, inlet manifold, timing gears, timing chains, timing belt/chain tensioner, flywheel or flex plate, starter ring gear. (excludes overheating, de-coking, burnt, pitted and sticking valves).

N.B. Failure of timing belt not covered.

Rotary Engine

Rotors, vanes, rotor seals, rotor central shaft.

Manual gearbox

Gears and gear clusters, selectors and shafts, synchromesh assemblies, ball and roller bearings, needle bearings, bushes and transfer gears.

Automatic gearbox

Governor, valve block, oil pump, gears, brake bands, clutches, seals, servos, shafts, bearings and bushes, modulator valve and transfer gears.

Brakes

Brake master cylinder.

Clutch

Clutch plate, pressure plate, release thrust bearing, oil contamination (centre plate only), master and slave cylinders, clutch cable including self-adjusting mechanism and clutch damper.

Differential

Internal shafts, bearings and bushes, thrust washers, spacers and bevel gears. Planetary gear assembly, crown wheel and pinion assembly. Includes front, rear and centre differentials (excludes viscous couplings and fluid differentials).

Front - Wheel Drive

Drive shafts, universal joints and couplings and constant velocity joints (excludes gaiters and bushes).

Rear - Wheel Drive

Drive shafts, universal joints and couplings, constant velocity joints, half shafts and bearings (excludes gaiters and bushes).

Engine Cooling System

Water pump.

Electrical System

Starter motor and alternator.

Subject to terms and conditions available on request.

Includes all the items within the driver cover plus the following

Engine

Timing belts are covered provided that the last due change of belt has taken place as specified by the manufacturer’s schedule (proof required).

Torque Converter

Failure of any internal mechanical parts. Continuously Variable Transmission (CVT/CTX) Internal clutches, planetary gears, reduction gears, shafts, variable pulleys, thrust link drives, internal seals, bushes and bearings.

Wheel Bearings

Front and rear wheel bearings.

Propshaft

Universal joints and couplings. Bearings and rubber couplings. Includes front and rear transfer shafts 4X4 vehicles (excludes gaiters).

Brakes

Wheel cylinders, callipers, brake bias/restrictor valve, vacuum servo and brake vacuum pump.

Fuel system (diesel and petrol)

Carburettors, automatic choke, lift pump, mechanical or electrical fuel pumps and tank sender unit.

Fuel injection system

Throttle body, airflow meter, idle control valve, cold start valve, warm up regulator, overrun cut off valve, throttle potentiometer, fuel accumulator, pressure regulator, map sensor (except injectors and heater plugs).

Front and rear suspension

Upper and lower wishbones, ball and swivel joints, anti roll bars, mountings, torsion bars and coil springs.

Engine Management (ECU)

Engine Electronic Control Unit.

Transfer Box (4X4)

Transfer gears, selectors, transfer shafts, needle and roller bearings, output shafts and bushes.

Engine Cooling System

Engine thermostat, thermostat housing, viscous fan coupling, engine temperature, gauge sensor, engine oil cooler, heater matrix, radiator and expansion tank.

Casings

If any of the covered parts fail and this damages the casing, it will also be covered.

Electrical

Voltage regulator, starter solenoid (inertia drive starters), indicator relay, front and rear windscreen wiper motor, front and rear windscreen washer motor, ignition coils, electric window motors and switches, horn, glow plug relay (diesel vehicles), electric sun roof motor and switch, central locking systems (excluding remote control unit and wiring), indicator and wiper switches (column stalks), heater fan motor, fuel tank sender unit, electric fuel pump, temperature sensing switch, oil pressure sensor, speedo head and speedo transducer, heated rear screen (element failure only), door mirror motors and switches.

Steering (Including power assisted steering)

Steering rack and pinion (not gaiters), steering box, power steering rack and pump, power steering reservoir and idler box.

Working Materials

Oils, oil filter and anti-freeze are covered only if it essential to replace them because of the failure of a part which is covered under this warranty.

Driver optional cover

The following items are covered if recorded on warranty record and additional cover payment made.

Turbocharger / Supercharger / Kompressor

The complete unit is covered providing it is of original manufacturer’s equipment (includes the wastegate if it is an integral part of the unit and cannot be bought separately).

Anti Lock Brake System (ABS)

Factory fitted ABS are covered (excludes wiring and connection faults).

Air Conditioning / Climate Control

Factory fitted systems are covered (excludes pipes, unions, wiring, receiver drier and cost of regassing).

Catalytic Converter

Factory fitted catalytic converters are covered (excludes damage caused by impact, corrosion or incorrect grade or type of fuel).

Subject to terms and conditions available on request.